M165920S Owner’s Manual Instructions for Installation/Set-up, Operation, Servicing, & Storage Portable, Outdoor Use-Only, Industrial Gasolin
Power Load Planning & Management 10 WARNING NEVER exceed the rated wattage capacity of you
Power Load Planning & Management (cont’d) 11 Device Running Watts Device Running Watts Furnace fan (1/3 HP) 1200 (a) Submersible pump (1-1/
Installation / Initial Set-Up 12 There are a number of important steps required to set up your gen
Installation / Initial Set-Up 13 3. Set-up either as a BUILDING BACK-UP or PORTABLE Power Source This generator is designed to provide up to 8000
Installation / Initial Set-Up 14 The generator cannot power your entire home -- you must work with the installing electrician to determine which d
Installation / Initial Set-Up 15 ♦ Make sure you plug each electrical device/appliance into the correct generator outlet based on the device’s pl
Installation / Initial Set-Up 16 4. Select a Suitable Site Before using the generator, you must select a suitable OUTDOOR location for installatio
Installation / Initial Set-Up 17Adequate cooling ventilation The generator needs adequate, unobstructed flow of air to allow for proper cooling of
Installation / Initial Set-Up 1810 Ga. wireCopperPipe/RodGrounding Post Ground 5. Grounding the generator Always ensure the generator is properly
Installation / Initial Set-Up 19 6. Battery Installation Your generator’s engine is equipped with an electric starter which requires the installa
Hazard Signal Word Definitions 2
Operation 20 Once you have set up your generator for use, it is time to start your generator. Th
Operation (cont’d) 21• Malfunction during operation. Immediately turn off the generator if any of the following conditions arise during operatio
Operation (cont’d) 22 Static electricity and filling the gasoline tank: Static electricity can initiate from ungrounded gasoline tanks or containe
Operation (cont’d) 23 2. Preparing for Operation Position generator Position generator in accordance with the instructions given in “Installation
Operation (cont’d) 24 WARNING: Gasoline fire/explosion hazard Gasoline is highly flammable and explosive. Heat, sparks, and flame
Operation (cont’d) 25vehicle, trailer, trunk, or pick-up truck bed. ALWAYS place container on the ground to be filled. • Keep nozzle in conta
Operation (cont’d) 26 3. Starting the Engine After you have completed the pre-start checklist procedures, you are ready to start the engine. To
Operation (cont’d) 27 4. Checking Generator Output Although the speed of the engine was carefully adjusted at the factory so that the generator p
Operation (cont’d) 28 5. Connecting Loads You will want to be careful when connecting loads so as not to overload the generator, especially if yo
Operation (cont’d) 29 7. Storage & Exercise When you are finished using the generator, you must: o Disconnect all loads o Shut off fuel su
Table of Contents 3 Hazard Signal Word Definitions ...
Operation (cont’d) 30Prepare engine for long term storage if needed If you will not be able to exercise the generator regularly, you must prepare
Maintenance & Repair 31 Inspect and maintain your generator as specified below in order to ke
Maintenance & Repair (cont’d) 32Inspect fuel system / check for leaks Inspect the fuel system and check for leaks on a regular basis. Inspect
Troubleshooting 33 TROUBLESHOOTING Problem Possible Causes Possible Remedies Engine wi
Summary of Important Safety Information for Operation 34 This section provides a summary of the v
Summary of Important Safety Information for Operation (cont’d) 35 Installation / Initial Set-up Safety • Dry, level surface. Situate generator on
Summary of Important Safety Information for Operation (cont’d) 36• Use approved container. Never pump fuel directly into engine at gas station.
Summary of Important Safety Information for Operation (cont’d) 37• Hot muffler. Never touch hot muffler, hot exhaust manifold, or engine cooling
Exploded View Rev - S 38
Exploded View Rev - S 39 Diag # Part # Description Qty 1 38759 Fuel Tank Assembly 1 2 33321
About Your Generator 4 Thank you for purchasing your NorthStar portable generator! About Your Ge
Wiring Diagram Rev - S 40
Wiring Diagram Rev - S 41 Diag # Part # Description Qty1 31344 GFCI Duplex Receptacle, NEMA 5-
Generator Head Exploded View Rev - S 42 Item # Part # Descr
Limited Warranty 43 Dear Valued Customer: The NorthStar Product you just purchased is built with
44 Manufactured by Northern Tool + Equipment Co
About Your Generator (cont’d) 5NorthStar is constantly improving its products. The specifications outlined herein are subject to change without p
Specifications 6 SPECIFICATIONS Item Number 165920 Maximum Output 8000 Watts (W) Continuous Out
Safety Label Locations 7 Always make sure safety labels are in place
Machine Component Identification - Item #165920S 8 Figure 1 (Ref. 1-13) Ref.
Machine Component Identification - Item #165920S 9REFERENCE GUIDE Reference 1 – Air Cleaner Refer to your Honda engine manual for air cleaner care
Kommentare zu diesen Handbüchern